CFR
- Title 1 - General Provisions
- Title 2 - Grants and Agreements
- Title 3 - The President
- Title 4 - Accounts
- Title 5 - Administrative Personnel
- Title 6 - Domestic Security
- Title 7 - Agriculture
- Title 8 - Aliens and Nationality
- Title 9 - Animals and Animal Products
- Title 10 - Energy
- Title 11 - Federal Elections
- Title 12 - Banks and Banking
- Title 13 - Business Credit and Assistance
- Title 14 - Aeronautics and Space
- Title 15 - Commerce and Foreign Trade
- Title 16 - Commercial Practices
- Title 17 - Commodity and Securities Exchanges
- Title 18 - Conservation of Power and Water Resources
- Title 19 - Customs Duties
- Title 20 - Employees' Benefits
- Title 21 - Food and Drugs
- Title 22 - Foreign Relations
- Title 23 - Highways
- Title 24 - Housing and Urban Development
- Title 25 - Indians
- Title 26 - Internal Revenue
- Title 27 - Alcohol, Tobacco Products and Firearms
- Title 28 - Judicial Administration
- Title 29 - Labor
- Title 30 - Mineral Resources
- Title 31 - Money and Finance: Treasury
- Title 32 - National Defense
- Title 33 - Navigation and Navigable Waters
- Title 34 - Education
- Title 35 - Panama Canal
- Title 36 - Parks, Forests, and Public Property
- Title 37 - Patents, Trademarks, and Copyrights
- Title 38 - Pensions, Bonuses, and Veterans' Relief
- Title 39 - Postal Service
- Title 40 - Protection of Environment
- Title 41 - Public Contracts and Property Management
- Title 42 - Public Health
- Title 43 - Public Lands: Interior
- Title 44 - Emergency Management and Assistance
- Title 45 - Public Welfare
- Title 46 - Shipping
- Title 47 - Telecommunication
- Title 48 - Federal Acquisition Regulations System
- Title 49 - Transportation
- Title 50 - Wildlife and Fisheries
430.55—New source performance standards (NSPS).
New sources subject to this subpart must achieve the following new source performance standards (NSPS), as applicable.
| [1982 NSPS] | |||||
| Pollutant or pollutantproperty | Kg/kkg (or pounds per 1,000 lb) of product | Continuous dischargers | Maximum for any 1 day | Average of daily values for 30 consecutive days | Non-continuous dischargers (annual average) |
|---|---|---|---|---|---|
| BOD5 | 4.38exp(0.017x) | 2.36exp(0.017x) | Average of daily values for 30 consecutive days divided by 1.91. | ||
| TSS | 5.81exp(0.017x) | 3.03exp(0.017x) | Average of daily values for 30 consecutive days divided by 1.90. | ||
| pH | (1) | (1) | (1) | ||
| x = percent sulfite pulp in final product | |||||
| 1 Within the range of 5.0 to 9.0 at all times. | |||||
(b)
The following standards apply with respect to each new source fiber line that commences discharge after June 15, 1998.
(1)
The following standards apply to all new sources in the calcium-, magnesium-, or sodium-based sulfite pulp segment:
| [Production of Calcium-, Magnesium-, or Sodium-based Sulfite Pulps] | |||||||
| Pollutant or pollutant property | NSPS | Continuous dischargers | Maximum for any 1 day | Monthly average | Non-continuous dischargers | Maximum for any 1 day | Annual average |
|---|---|---|---|---|---|---|---|
| kg/kkg (or pounds per 1,000 lb) of product | |||||||
| AOX | <ML a | (b) | <ML a | (b) | |||
| COD | (c) | (c) | (c) | (c) | |||
| a “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | |||||||
| b This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | |||||||
| c [Reserved] | |||||||
(2)
(i)
The following standards apply to all new sources in the ammonium-based sulfite pulp segment:
| Pollutant or pollutant property | NSPS | |
|---|---|---|
| Maximum for any 1 day | Monthly average | |
| TCDD a | <ML b | (c) |
| TCDF a | <ML b | (c) |
| Chloroform a | (d) | (d) |
| Trichlorosyringol a | <ML b | (c) |
| 3,4,5-trichlorocatechol a | <ML b | (c) |
| 3,4,6-trichlorocatechol a | <ML b | (c) |
| 3,4,5-trichloroguaiacol a | <ML b | (c) |
| 3,4,6-trichloroguaiacol a | <ML b | (c) |
| 4,5,6-trichloroguaiacol a | <ML b | (c) |
|
Code of Federal Regulations
159
|
||
| 2,4,5-trichlorophenol a | <ML b | (c) |
| 2,4,6-trichlorophenol a | <ML b | (c) |
| Tetrachlorocatechol a | <ML b | (c) |
| Tetrachloroguaiacol a | <ML b | (c) |
| 2,3,4,6-tetrachlorophenol a | <ML b | (c) |
| Pentachlorophenol a | <ML b | (c) |
| Continuous dischargers | Non-continuousdischargers | |||
|---|---|---|---|---|
| Maximum for any 1 day | Monthlyaverage | Maximum for any 1 day | Annualaverage | |
| kg/kkg (or pounds per 1,000 lb) of product | ||||
| AOX | (d) | (d) | (d) | (d) |
| COD | (d) | (d) | (d) | (d) |
| a These limitations do not apply with respect to fiber lines that use a TCF bleaching process as disclosed by the discharger in its permit application under 40 CFR 122.21(g)(3) and certified under 40 CFR 122.22 . | ||||
| b “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | ||||
| c This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | ||||
| d [Reserved] | ||||
(ii)
The following standards apply to all new sources in the ammonium-based sulfite pulp segment with respect to each fiber line that uses exclusively TCF bleaching processes, as disclosed by the discharger in its NPDES permit application under 40 CFR 122.21(g)(3) and certified under 40 CFR 122.22 :
| Pollutant or pollutant property | NSPS (TCF) | Continuous dischargers | Maximum for any 1 day | Monthly average | Non-continuous dischargers | Maximum for any 1 day | Annual average |
|---|---|---|---|---|---|---|---|
| kg/kkg (or pounds per 1,000 lb) of product | |||||||
| AOX | <ML a | (b) | <ML a | (b) | |||
| COD | (c) | (c) | (c) | (c) | |||
| a “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | |||||||
| b This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | |||||||
| c [Reserved] | |||||||
(3)
(i)
The following standards apply to all new sources in the specialty grade sulfite pulp segment:
| Pollutant or pollutant property | NSPS | |
|---|---|---|
| Maximum for any 1 day | Monthly average | |
| TCDD a | <ML b | (c) |
| TCDF a | <ML b | (c) |
| Chloroform a | (d) | (d) |
| Trichlorosyringol a | <ML b | (c) |
| 3,4,5-trichlorocatechol a | <ML b | (c) |
| 3,4,6-trichlorocatechol a | <ML b | (c) |
| 3,4,5-trichloroguaiacol a | <ML b | (c) |
| 3,4,6-trichloroguaiacol a | <ML b | (c) |
| 4,5,6-trichloroguaiacol a | <ML b | (c) |
| 2,4,5-trichlorophenol a | <ML b | (c) |
|
Code of Federal Regulations
160
|
||
| 2,4,6-trichlorophenol a | <ML b | (c) |
| Tetrachlorocatechol a | <ML b | (c) |
| Tetrachloroguaiacol | <ML b | (c) |
| 2,3,4,6-tetrachlorophenol a | <ML b | (c) |
| Pentachlorophenol a | <ML b | (c) |
| Continuous dischargers | Non-continuousdischargers | |||
|---|---|---|---|---|
| Maximum for any 1 day | Monthlyaverage | Maximum for any 1 day | Annualaverage | |
| kg/kkg (or pounds per 1,000 lb) of product | ||||
| AOX | (d) | (d) | (d) | (d) |
| COD | (d) | (d) | (d) | (d) |
| a These limitations do not apply with respect to fiber lines that use a TCF bleaching process as disclosed by the discharger in its permit application under 40 CFR 122.21(g)(3) and certified under 40 CFR 122.22 . | ||||
| b “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | ||||
| c This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | ||||
| d [Reserved] | ||||
(ii)
The following standards apply to all new sources within the specialty grade sulfite pulp segment with respect to each fiber line that uses exclusively TCF bleaching processes, as disclosed by the discharger in its NPDES permit application under 40 CFR 122.21(g)(3) and certified under 40 CFR 122.22 :
| Pollutant or pollutant property | NSPS (TCF) | Continuous dischargers | Maximum for any 1 day | Monthly average | Non-continuous dischargers | Maximum for any 1 day | Annual average |
|---|---|---|---|---|---|---|---|
| kg/kkg (or pounds per 1,000 lb) of product | |||||||
| AOX | <ML a | (b) | <ML a | (b) | |||
| COD | (c) | (c) | (c) | (c) | |||
| a “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | |||||||
| b This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | |||||||
| c [Reserved] | |||||||
(c)
The following standards apply to each new source regardless of when it commenced discharge, unless it certifies to the permitting authority that it is not using these compounds as biocides. Also, for non-continuous dischargers, concentration limitations (mg/l) shall apply. Concentration limitations will only apply to non-continuous dischargers:
| [Supplemental NSPS] | ||
| Pollutant or pollutant property | Maximum for any 1 day | |
|---|---|---|
| kg/kkg (or pounds per 1,000 lb) of product | Milligrams/liter | |
| Pentachlorophenol | 0.00058exp(0.017x) | ((0.015)(9.12)exp(0.017x))/y |
| Trichlorophenol | 0.0036exp(0.017x) | ((0.094)(9.12)exp(0.017x))/y |
| x = percent sulfite pulp in final product. | ||
| y = wastewater discharged in kgal per ton of product. | ||
|
Code of Federal Regulations
161
|
||
(d)
Pursuant to 40 CFR 122.44(i) and 122.45(h), a discharger must demonstrate compliance with the standards in paragraphs (b)(2) or (b)(3) of this section, as applicable, by monitoring for all pollutants (except for AOX, COD, BOD5, TSS, and pH) at the point where the wastewater containing those pollutants leaves the bleach plant. The permitting authority may impose effluent limitations and/or monitoring requirements on internal wastestreams for any other pollutants covered in this section as appropriate under 40 CFR 122.44(i) and 122.45(h).
New sources subject to this subpart must achieve the following new source performance standards (NSPS), as applicable.
| [1982 NSPS] | |||||
| Pollutant or pollutantproperty | Kg/kkg (or pounds per 1,000 lb) of product | Continuous dischargers | Maximum for any 1 day | Average of daily values for 30 consecutive days | Non-continuous dischargers (annual average) |
|---|---|---|---|---|---|
| BOD5 | 4.38exp(0.017x) | 2.36exp(0.017x) | Average of daily values for 30 consecutive days divided by 1.91. | ||
| TSS | 5.81exp(0.017x) | 3.03exp(0.017x) | Average of daily values for 30 consecutive days divided by 1.90. | ||
| pH | (1) | (1) | (1) | ||
| x = percent sulfite pulp in final product | |||||
| 1 Within the range of 5.0 to 9.0 at all times. | |||||
(b)
The following standards apply with respect to each new source fiber line that commences discharge after June 15, 1998.
(1)
The following standards apply to all new sources in the calcium-, magnesium-, or sodium-based sulfite pulp segment:
| [Production of Calcium-, Magnesium-, or Sodium-based Sulfite Pulps] | |||||||
| Pollutant or pollutant property | NSPS | Continuous dischargers | Maximum for any 1 day | Monthly average | Non-continuous dischargers | Maximum for any 1 day | Annual average |
|---|---|---|---|---|---|---|---|
| kg/kkg (or pounds per 1,000 lb) of product | |||||||
| AOX | <ML a | (b) | <ML a | (b) | |||
| COD | (c) | (c) | (c) | (c) | |||
| a “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | |||||||
| b This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | |||||||
| c [Reserved] | |||||||
(2)
(i)
The following standards apply to all new sources in the ammonium-based sulfite pulp segment:
| Pollutant or pollutant property | NSPS | |
|---|---|---|
| Maximum for any 1 day | Monthly average | |
| TCDD a | <ML b | (c) |
| TCDF a | <ML b | (c) |
| Chloroform a | (d) | (d) |
| Trichlorosyringol a | <ML b | (c) |
| 3,4,5-trichlorocatechol a | <ML b | (c) |
| 3,4,6-trichlorocatechol a | <ML b | (c) |
| 3,4,5-trichloroguaiacol a | <ML b | (c) |
| 3,4,6-trichloroguaiacol a | <ML b | (c) |
| 4,5,6-trichloroguaiacol a | <ML b | (c) |
|
Code of Federal Regulations
159
|
||
| 2,4,5-trichlorophenol a | <ML b | (c) |
| 2,4,6-trichlorophenol a | <ML b | (c) |
| Tetrachlorocatechol a | <ML b | (c) |
| Tetrachloroguaiacol a | <ML b | (c) |
| 2,3,4,6-tetrachlorophenol a | <ML b | (c) |
| Pentachlorophenol a | <ML b | (c) |
| Continuous dischargers | Non-continuousdischargers | |||
|---|---|---|---|---|
| Maximum for any 1 day | Monthlyaverage | Maximum for any 1 day | Annualaverage | |
| kg/kkg (or pounds per 1,000 lb) of product | ||||
| AOX | (d) | (d) | (d) | (d) |
| COD | (d) | (d) | (d) | (d) |
| a These limitations do not apply with respect to fiber lines that use a TCF bleaching process as disclosed by the discharger in its permit application under 40 CFR 122.21(g)(3) and certified under 40 CFR 122.22 . | ||||
| b “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | ||||
| c This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | ||||
| d [Reserved] | ||||
(ii)
The following standards apply to all new sources in the ammonium-based sulfite pulp segment with respect to each fiber line that uses exclusively TCF bleaching processes, as disclosed by the discharger in its NPDES permit application under 40 CFR 122.21(g)(3) and certified under 40 CFR 122.22 :
| Pollutant or pollutant property | NSPS (TCF) | Continuous dischargers | Maximum for any 1 day | Monthly average | Non-continuous dischargers | Maximum for any 1 day | Annual average |
|---|---|---|---|---|---|---|---|
| kg/kkg (or pounds per 1,000 lb) of product | |||||||
| AOX | <ML a | (b) | <ML a | (b) | |||
| COD | (c) | (c) | (c) | (c) | |||
| a “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | |||||||
| b This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | |||||||
| c [Reserved] | |||||||
(3)
(i)
The following standards apply to all new sources in the specialty grade sulfite pulp segment:
| Pollutant or pollutant property | NSPS | |
|---|---|---|
| Maximum for any 1 day | Monthly average | |
| TCDD a | <ML b | (c) |
| TCDF a | <ML b | (c) |
| Chloroform a | (d) | (d) |
| Trichlorosyringol a | <ML b | (c) |
| 3,4,5-trichlorocatechol a | <ML b | (c) |
| 3,4,6-trichlorocatechol a | <ML b | (c) |
| 3,4,5-trichloroguaiacol a | <ML b | (c) |
| 3,4,6-trichloroguaiacol a | <ML b | (c) |
| 4,5,6-trichloroguaiacol a | <ML b | (c) |
| 2,4,5-trichlorophenol a | <ML b | (c) |
|
Code of Federal Regulations
160
|
||
| 2,4,6-trichlorophenol a | <ML b | (c) |
| Tetrachlorocatechol a | <ML b | (c) |
| Tetrachloroguaiacol | <ML b | (c) |
| 2,3,4,6-tetrachlorophenol a | <ML b | (c) |
| Pentachlorophenol a | <ML b | (c) |
| Continuous dischargers | Non-continuousdischargers | |||
|---|---|---|---|---|
| Maximum for any 1 day | Monthlyaverage | Maximum for any 1 day | Annualaverage | |
| kg/kkg (or pounds per 1,000 lb) of product | ||||
| AOX | (d) | (d) | (d) | (d) |
| COD | (d) | (d) | (d) | (d) |
| a These limitations do not apply with respect to fiber lines that use a TCF bleaching process as disclosed by the discharger in its permit application under 40 CFR 122.21(g)(3) and certified under 40 CFR 122.22 . | ||||
| b “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | ||||
| c This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | ||||
| d [Reserved] | ||||
(ii)
The following standards apply to all new sources within the specialty grade sulfite pulp segment with respect to each fiber line that uses exclusively TCF bleaching processes, as disclosed by the discharger in its NPDES permit application under 40 CFR 122.21(g)(3) and certified under 40 CFR 122.22 :
| Pollutant or pollutant property | NSPS (TCF) | Continuous dischargers | Maximum for any 1 day | Monthly average | Non-continuous dischargers | Maximum for any 1 day | Annual average |
|---|---|---|---|---|---|---|---|
| kg/kkg (or pounds per 1,000 lb) of product | |||||||
| AOX | <ML a | (b) | <ML a | (b) | |||
| COD | (c) | (c) | (c) | (c) | |||
| a “<ML” means less than the minimum level specified in § 430.01(i) for the particular pollutant. | |||||||
| b This regulation does not specify this type of limitation for this pollutant; however, permitting authorities may do so as appropriate. | |||||||
| c [Reserved] | |||||||
(c)
The following standards apply to each new source regardless of when it commenced discharge, unless it certifies to the permitting authority that it is not using these compounds as biocides. Also, for non-continuous dischargers, concentration limitations (mg/l) shall apply. Concentration limitations will only apply to non-continuous dischargers: